成果報告書詳細
管理番号20100000001596
タイトル*平成21年度中間年報 新エネルギー技術フィールドテスト事業 地域バイオマス熱利用フィールドテスト事業 都市域廃棄物のガス化・メタノール合成による地域エネルギーシステム実用化に関する実証試験事業
公開日2010/9/30
報告書年度2009 - 2009
委託先名清水建設株式会社
プロジェクト番号P07018
部署名新エネルギー技術開発部
和文要約和文要約等以下本編抜粋:1. 共同研究の内容及び成果等 装置設置場所である清水建設株式会社東京木工場で実証事業を行っている。主な共同研究内容を以下に記す。 (1)バイオマスガス化発電装置の各機能確認・設定、試運転調整 ガス化・発電装置の技術である「浮遊外熱式高カロリーガス化法」を用いた本実証試験事業について、ガス化・発電装置の温度・圧力などの計測設定確認、各種電動機・空圧制御回転数調整、反応管バイオマス定量供給フィーダ回転数などの各供給装置確認調整、空圧アクチュエータ調整、各種ファン・バーナなどの各部調整を行った。 また、メタノール合成装置導入後にはガス化装置の試運転調整を行い、装置全体での計測機器データ、バイオマス供給量、反応水供給量、反応炉内温度と圧力、発生ガス量の調整を行った。
英文要約Title: Demonstration experiment project of gasification and methanol production using Urban-biomass (FY2008-2010) FY2009 Annual Report
1. Purpose of the project:The purpose of this demonstration project is to establish a biomass energy conversion system using urban-biomass like paper waste or wood waste by gasification/electricity generation or gasification/methanol production. The demonstration plant was installed at Shimizu’s Tokyo woodworking plant, located at downtown area of Tokyo. The main results are as follows.:2. Research and development results:(1)Full test run of the equipment:This equipment is using the floating type high calorie gasification by outside heating. We had checked the setup condition of the devices in the biomass energy conversion system, like temperature and pressure of gasification and electricity generation equipment, rotational frequency of every motor and fan, supply rate of biomass feeder, air-pressure of actuator, and so on. Especially, the full test run of the entire system had been done following the installation of the methanol production equipment, acquiring various data of measurement, volume of supplied biomass and reaction water, temperature and pressure of reactor, and so on.:(2) Gasification and electricity generation equipment:The field test of gasification and electricity generation equipment was done. We continually examined the basic and optimum conditions of temperature and pressure of various devices, speed control of generator and feeder, etc. In a field test, the wood chip and the wood powder are made with the disintegrator. Those raw materials are discharged from the woodworking plant.:(3)Methanol synthesis equipment:Methanol synthesis equipment was examined in factory inspection. H2 reduction operation of catalyst and preliminary methanol synthesis experiments was done.:(4)Holding of the Evaluation committee:On August 2009, the second Evaluation committee of this demonstration project was held inviting experts in gasification technology and building technology. Many valuable comments and suggestions were obtained through the meeting.
ダウンロード成果報告書データベース(ユーザ登録必須)から、ダウンロードしてください。

▲トップに戻る